APCD Hearing Board Agenda – September 3, 2014

September 3, 2014     (Agenda)    (Meeting Continued to May 6, 2015)

I.         9:30 a.m. – Call to Order – Roll Call

II.        Election of Chair and Vice-Chair for 2014

III.      Administration of Oath to Participants

IV.      Approval of minutes of the November 6, 2013 meeting

V.        Requests for continuance or addition of Ex-Agenda items

VI.      Announcements/Staff Reports

VII.     Public Comment Period

VIII.    Public Hearings

1)         Case No. – 20-14-RE –   Respondent:  Gordon Sand Company; a California Corporation 28310 Industrial Blvd., #F, Hayward, CA 94545

Hearing – To consider a petition by the Control Officer of the Santa Barbara County Air Pollution Control District, for issuance of an Order of Revocation of Permit to Operate 8351-R8 pursuant to Health and Safety Code section 42307 and 42309(e).  Gordon Sand Company is the holder of Permit to Operate 8351-R8 and is the owner and operator of the air pollution emitting equipment located at the facility located on Main Street three miles west of the City of Guadalupe in the Guadalupe Dunes, Guadalupe, CA 93434, in violation of District Rule 210.V(A)(2)

IX.        Administrative Agenda

Approved by vote on one motion.  These items read only on request of Hearing Board members.  The following Variance Orders have been approved by the Air Pollution Control District Hearing Board.  These orders are available for inspection and reproduction at the Office of the Air Pollution Control District:

A-1)      Case No.  – 22-13-E – Greka Oil & Gas, Inc., P.O. Box 5489, Santa Maria, CA  93456
On November 1, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of October 31, 2013 through November 30, 2013.  Said variance provides relief from specific requirements of District Rule 325.E.1 and allows for continued operation of Battles Lease Tank Battery while repairs can be made off-site to a gas leak in the Vapor Recovery System compressor.

A-2)      Case No.  – 01-14-I – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455, On January 7, 2014 Hearing Board member David Schmarje approved an Interim Variance for the period of January 6, 2014 through March 28, 2014 or the date of decision regarding Petitioner’s request for a 90-Day Variance, whichever occurs first.  Said variance provides relief from District Rule 206, Condition 9.C.2.(a) of Permit to Operate 9105 and allows for continued operation of Turbine Generator G-92 while the cause of excess CO emissions is evaluated and corrections made.

A-3)      Case No.  – 02-14-N – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On January 29, 2014 Hearing Board member Larry Lavagnino approved a 90-Day Variance for the period of January 29, 2014 through March 28, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.2.(a) of Permit to Operate 9105 and allows for continued operation of Turbine Generator G-92 while the cause of excess CO emissions is evaluated and corrections made.

A-4)      Case No.  – 03-14-E – Greka Oil & Gas, Inc. P.O. Box 5489, Santa Maria, CA  93456
On January 16, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of January 14, 2014 through January 28, 2014.  Said variance provides relief from District Rule 331 and allows for the continued operation of Petitioner’s Bell Lease Tank Battery while repairs are made to a gas leak in the compressor crank shaft seal.

A-5)      Case No.  – 04-14-E – Greka Oil & Gas, Inc., P.O. Box 5489, Santa Maria, CA  93456
On January 23, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of January 22, 2014 through January 29, 2014.  Said variance provides relief from District Rule 325.E.1 and allows for the continued operation of Petitioner’s Union Sugar Lease with the Field Gas Compressor operating as the only on-site Vapor Recovery Compressor (VRC) while repairs are made to the main VRC.

A-6)      Case No.  – 05-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On January 23, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of January 23, 2014 through February 21, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.2(c)(i) and Condition 9.C.2(d)(iv) of Permit to Operate 5704 and allows for the continued operation of Petitioner’s Gaviota Oil & Heating Facility while repairs can be made to an inoperable Gas Chromatograph.

A-7)      Case No.  – 06-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On January 29, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of January 29, 2014 through February 26, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.1(a) of Permit to Operate 9106 and Rule 333.E.4 and allows for the continued operation of Platform Irene North Crane Engine while the source of excess NOx emissions is evaluated and corrections made.

A-8)      Case No.  – 07-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On February 10, 2014 Hearing Board member Robert Saperstein approved an Emergency Variance for the period of February 7, 2014 through March 8, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.2(c)(iv) of Permit to Operate 9106 and allows for the continued operation of Platform Irene while repairs are made to a failed H2S analyzer.

A-9)      Case No.  – 08-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On February 13, 2014 Hearing Board member Donald Ward approved an Emergency Variance for the period of February 11, 2014 through February 26, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.21(b)(i) of Permit to Operate 9106 and allows for the continued operation of Platform Irene with continuous use of emergency standby diesel-fueled CI engine while the electric pump is being replaced.

A-10)    Case No.  – 09-14-E – Pacific Coast Energy Company, 1555 Orcutt Hill Road, Orcutt, CA  93455
On March 13, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of March 14, 2014 through March 16, 2014.  Said variance provides relief from District Rule 325.D.1(a) and District Rule 206, Condition 9.C.7(b)(ii) of Permit to Operate 8240 and 2(b) of Permit to Operate 12084-R3 and allows for continued operation of the facility during a PG&E scheduled power outage.

A-11)    Case No.  – 10-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On March 19, 2014 Hearing Board member Robert Saperstein approved an Emergency Variance for the period of March 24, 2014 through April 23, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.2(a) of Permit to Operate 9103 and allows for limited operation of Platform Harvest G-700B Turbine while maintenance is performed to reduce excess ROC emissions.

A-12)    Case No.  – 11-14-E – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On March 26, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of March 25, 2014 through April 9, 2014.  Said variance provides relief from District Rule 206, Conditions 9.C.2(a), 9.C.2(b)(iv) and 9.C.2(b)(xi) of Part 70/Permit to Operate 8092 for the continued operation of the Thermal Oxidizer (A-803) while the system is purged and any potential additional sources of elevated H2S are identified and remediated.

A-13)    Case No.  – 12-14-N – Southern California Gas Co., P.O. Box 5489, Santa Maria, CA  93456
On May 8, 2014 Hearing Board member Larry Lavagnino approved a 90-Day Variance for the period of September 1, 2014 through November 29, 2014, or the date that the break-in period of the engine is complete, whichever occurs first, and not to exceed 150 hours of engine run-time.  Said variance provides relief from District Rule 206, Conditions 9.C.1(a), 9.C.1(b)(iv), 9.C.1(b)(v) and 9.C.1(b)(vi)(A) of Part 70 Permit to Operate 9584-R4 and District Rule 333 E.1(a) and allows for continued operation of Petitioner’s Main Unit #2 during the post-overhaul “break-in” period of the engine and compressor.

A-14)    Case No.  – 13-14-E – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On April 18, 2014 Hearing Board member Robert Saperstein approved an Emergency Variance for the period of April 17, 2014 through May 16, 2014.  Said variance provides relief from District Rule 206, Conditions 9.C.6(b)(iv) and 9.C.6(b)(v) of Part 70/Permit to Operate 5651 and allows for continued operation of the equalization tank while maintenance on the system is performed, and the cause of the lack of flow is identified and remediated.

A-15)    Case No.  – 14-14-E – Imerys Minerals California, 2500 Miguelito Road, Lompoc, CA  93436
On May 2, 2014 Hearing Board member Robert Saperstein approved an Emergency Variance for the period of April 25, 2014 through May 24, 2014.  Said variance provides relief from District Rule 302 and District Rule 206, Condition 9.B(2) of Part 70/Permits to Operate 5840 and 12105 and allows for the continued operation of 6 system and 7 system while repairs are made to the kiln heads.

A-16)    Case No.  – 15-14-E – Mission Hills Community Services District, 1550 E. Burton Mesa Blvd., Lompoc, CA  93436
On April 29, 2014 Hearing Board member Donald Ward approved an Emergency Variance for the period of April 29, 2014 through May 28, 2014.  Said variance provides relief from District Rule 206, Condition 6(a) and Table 5 of Permit to Operate 11886 and allows for limited operation of Petitioner’s Water Pump in order to conduct source testing.

A-17)    Case No.  – 16-14-E – Freeport-McMoRan Oil & Gas, 201 South Broadway, Orcutt, CA  93455
On May 9, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of May 10, 2014 through June 8, 2014.  Said variance provides relief from District Rule 331.E.1(f) and allows for the continued operation of Petitioner’s Well C-11 while repairs are made to a hydrocarbon leak.

A-18)    Case No.  – 17-14-I – Imerys Minerals California, 2500 Miguelito Road, Lompoc, CA  93436
On May 29, 2014 Hearing Board member Robert Saperstein approved an Interim Variance for the period of May 25, 2014 through August 12, 2014, or the date of decision on Petitioner’s request for a 90-Day Variance, whichever occurs first.  Said variance provides relief from District Rule 302 and District Rule 206, Condition 9.B(2) of Part 70/Permits to Operate 5840 and 12105 and allows for continued operation of 7 system while testing of the repaired kiln head is completed.

A-19)    Case No.  – 18-14-N – Imerys Minerals California, 2500 Miguelito Road, Lompoc, CA  93436
On June 10, 2014 Hearing Board member Robert Saperstein approved a 90-Day Variance for the period of May 25, 2014 through August 22, 2014, or until the date compliance is achieved, whichever occurs first.  Said variance provides relief from District Rule 302 and District Rule 206, Condition 9.B(2) of Part 70/Permits to Operate 5840 and 12105 and allows for continued operation of 7 system while testing of the repaired kiln head is completed.

A-20)    Case No.  – 19-14-E – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On June 6, 2014 Hearing Board member David Schmarje approved an Emergency Variance for the period of June 4, 2014 through July 3, 2014.  Said variance provides relief from District Rule 206, Conditions 9.C.12, 9.C.12(a) and 9.C.12(b) of Part 70/Permit to Operate 8092 and allows for continued operation of the Stretford Unit tail gas H2S analyzer until it can be repaired and any potential additional constituents in the tail gas stream are identified and remediated.

A-21)    Case No.  – 21-14-I – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On July 2, 2014 Hearing Board member David Schmarje approved an Interim Variance for the period of July 4, 2014 through October 1, 2014, or until the date of decision on Petitioner’s request for a 90-Day Variance, whichever occurs first.  Said variance provides relief from District Rule 328 and Rule 206, Conditions 9.C.12, 9.C.12(a) and 9.C.12(b) of Part 70/Permit to Operate 8092 and allows for continued operation of the Stretford Unit tail gas H2S analyzer until it can be repaired and any potential additional constituents in the tail gas stream are identified and remediated.

A-22)    Case No.  – 22-14-N – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On July 16, 2014 Hearing Board member David Schmarje approved a 90-Day Variance for the period of July 4, 2014 through October 1, 2014, or the date compliance is achieved, whichever occurs first.  Said variance provides relief from District Rule 328 and Rule 206, Conditions 9.C.12, 9.C.12(a) and 9.C.12(b) of Part 70/Permit to Operate 8092 and allows for continued operation of the Stretford Unit tail gas H2S analyzer until it can be repaired and any potential additional constituents in the tail gas stream are identified and remediated.

A-23)    Case No.  – 23-14-E – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On July 1, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of July 1, 2014 through July 30, 2014.  Said variance provides relief from District Rule 333 and Rule 206, Condition 9.C.1(c)(ii) of Part 70/Permit to Operate 9102 and allows for continued operation of the east pedestal crane while maintenance on the crane is performed.

A-24)    Case No. – 24-14-E – Pacific Coast Energy Company, 1555 Orcutt Hill Road, Orcutt, CA  93455
On July 25, 2014 Hearing Board member Robert Saperstein approved an Emergency Variance for the period of July 22, 2014 through August 5, 2014.  Said variance provides relief from District Rule 325 D.1(a) and Rule 206 Conditions 9.C.7(a), 9.C.9 and 9.D.6 of Permit to Operate 08240 and allows for the continued operation of Petitioner’s facility while corrections are made to eliminate the tank venting.

A-25)    Case No. – 25-14-E – ExxonMobil Production Company, 12000 Calle Real, Goleta, CA  93117
On August 8, 2014 Hearing Board member Larry Lavagnino approved an Emergency Variance for the period of August 1, 2014 through August 30, 2014.  Said variance provides relief from District Rule 206, Condition C.5(a)(i) of Part 70/Permit to Operate 8092 and allows for continued operation of Petitioner’s gas processing plant while the cause of the ice plugging is resolved.

A-26)    Case No. – 26-14-E – Biosphere Industries, 1025 Cindy Lane, Carpinteria, CA  93013
On August 11, 2014 Hearing Board member David Schmarje approved an Emergency Variance for the period of August 11, 2014 through September 9, 2014.  Said variance provides relief from District Rule 206, Condition 3.e of Permit to Operate 13173 and allows for continued operation of the Thermal Oxidizer without a data logger, while a new data logger can be obtained and installed.

A-27)    Case No. – 27-14-E – Imerys Minerals California, 2500 Miguelito Road, Lompoc, CA  93436
On August 13, 2014 Hearing Board member Donald Ward approved an Emergency Variance for the period of August 11, 2014 through August 25, 2014.  Said variance provides relief from District Rule 206, Condition 9.C.13(f) of Part 70 Permit to Operate 5840 and Permit to Operate 12105 and allows for continued operation of Petitioner’s Thermal Oxidizer while the cause of website downtime is found and remedied.

Adjourn